Effect Of Pre-Storage Steam Treatment On Shelf-Life of Kings’ Orange (Citrus Sinensis CV. Nobilis) Fruits During Ambient Storage
Abstract
Fresh fruits are susceptible to fungal rots, but postharvest decay control can be applied by physical, chemical, biological, and cultural techniques. Uninoculated ‘Kings’ orange (Citrus sinensis cv. Nobilis) fruits exposed to steam prior to ambient storage were analyzed for quality. Rot occurrence was between 3.3 and 13.3 % weekly increasing with storage. There was no definite trend especially after the first two weeks though initially higher on the most severely heated fruits. Penicillium digitatum, Lasiodiplodia theobromae and Aspergillus niger were associated with rots. Weekly and cumulative weight losses were highest among fruits that received the mildest heat treatment at 55 ͦ C for 25 minutes. Juice content was higher in steam treated fruits though not statistically significantly. Juice pH was more significantly affected by heating as the more severe heat treatments resulted into less acid in the first two weeks but more, later in storage. Titratable acid content was 0.48 to 0.77. In the fifth week, slightly significant reduction in titratable acid occurred in fruits that were heated at 60 ͦ C for 25 minutes compared with control, but it was more significant in comparison with juice from fruits heated at the lower temperature. There were increases in total soluble solids content with storage but insignificant differences between treatments. These results show that the presently applied steam treatments did not have significant undesirable effect on the fruit juice quality during subsequent ambient storage of fruits.
Full Text:
PDFReferences
A.T. Aborisade, “Heat treatment against the green mould on sweet orange (Citrus sinensis L. Osbeck) fruits at tropical ambient storage,” Acta Horticulturae, vol. 1079, pp. 319–323, 2014.
A.T. Aborisade and A.A. Ajibade, “Effect of pre-storage curing on storage life, internal and external qualities of sweet orange (Citrus sinensis),” Revista Brasileira de Fruticultura, vol. 32(3). doi:10.1590/s0100-29452010000300034. ISSN 0100-2945, 2010.
A.T. Aborisade and O.O. Elufisan, “Extension of shelf life of Penicillium digitatum infected sweet Oranges by vapour heat treatment,” Acta Horticulturae, vol. 1325, pp. 41-46, 2021. https://doi.org/10.17660/ActaHortic.2021.1327.7
V.A. Adisa and A.O. Fajola, “Postharvest fruit rots of three species of Citrus in South Western Nigeria,”. Indian Phytopathology, vol. 35, pp. 595–603, 1982.
S. Ben – Yehoshua, B. Shapiro and R. Moran, “Individual seal packaging enables the use of curing at high temperatures to reduce decay and heal injury of Citrus fruits,” HortScience, vol. 22(5), pp. 777–783, 1987.
M. Buccheri, M. Grassi, G. Bianchi, F. Lovati, M. Vanoli … D. Croce, “Postharvest physiology, nutritional quality and aroma profile of ‘Tarocco’ blood orange fruit (Citrus sinensis L. Osbeck),”. Acta Horticulturae, vol. 1079, pp. 291–298, 2014.
S. D’Aquino, A. Piga, M. Agabbio and T.G. McCollum, “Film wrapping delays ageing of ‘Minnela’ tangelos under shelf-life conditions,” Postharvest Biology and Technology, vol. 14, pp. 107-116, 1998.
E. Dreassi, A. Zanfini, A.T. Zizzari, C. La Rosa, M. Botta, G. Corbini, “Lc/Esi/Ms/Ms determination of postharvest fungicide residues in citrus juices,” LWT – Food Science and Technology, vol. 43(9), pp. 1301 – 1306, 2010. https://doi.org/10.1016/j.lwt.2010.04.010
S. Droby, A. Eick, D. Macarisin, L. Cohen, G. Rafael … R. Shapira, “Role of citrus volatiles in host recognition, germination, and growth of Penicillium digitatum and Penicillium italicum,” Postharvest Biology and Technology, vol. 49(3), pp. 386–396, 2008.
J.W. Eckhert, “Postharvest diseases of Citrus fruits,” Outlook on Agriculture, vol. 9(5), 1978. https://doi.org/10.1177/003072707800900506
J.W. Eckert, M. Ratnayake, “Role of volatile compounds from wounded Oranges in induction of germination of Penicillium digitatum conidia,” Phytopathology, vol. 84, pp. 746-750, 1994.
A. Erasmus, C.L. Lennox, J.L. Smilanick, K. Lesar and P.H. Fourie, “Imazalil residue loading and green mould control on Citrus fruit as affected by formulation, solution pH and exposure time in aqueous dip treatments,” Postharvest Biology and Technology, vol. 77, pp. 43 – 49, 2013. https://doi.org/10.1016/j.postharvbio.2012.11.001
E. Fallik, S. Alkalai-Tuvia and D. Chalupowicz, “Hot water rinsing and brushing of fresh produce as an alternative to chemical treatment after harvest – the story behind the technology,” Agronomy, vol. 11(8), 1653, 2021.
C.F. Forney, G.S. Bezanson, T.C. Ells, L. Fan and D.I. LeBlanc, “Impact of heat sanitation of fresh whole cantaloupe on fruit quality and volatile metabolism,” Acta Horticulturae, vol. 1079, pp. 145 – 151, 2015.
F. Gasser, C. Good and A. Naef, “Hot water treatment of selected organic apple and Pear cultivars,” Acta Horticulturae, vol. 1079, pp. 391 – 396, 2015.
M.A. Gatto, A. Ippolito, L. Sergio and D. Di Venere, “Extracts from wild edible herbs for controlling postharvest rots of fruit and vegetables,” Acta Horticulturae, vol. 1144, pp. 349 – 354, 2016. https://doi.org/10.17660/ActaHortic.2016.1144.51
D.B. Queb-Gonzalez, A. Lopez-Malo, M.E. Sosa-Morales and R. Villa-Rojas, “Postharvest heat treatments to inhibit Penicillium digitatum growth and maintain quality of mandarin (Citrus reticulata Blanco),” Heliyon, vol. 6(1), e03166. https://doi:10.1016/j.heliyon.2020.e03166,2020.
Y. Huang, B.J. Deverall and S.C. Morris, “Postharvest control of green mould on orange by a strain of Pseudomonas glathei and enhancement of its biocontrol by heat treatment,” Postharvest Biology and Technology, vol. 5, pp. 129–137, 1994.
S.V. Irtwange, “Hot water treatment: a non-chemical alternative in keeping quality during postharvest handling of Citrus fruits,” Agricultural Engineering International: CIGR Ejournal, vol. 8(5), pp. 1 – 10, 2006.
M. Ismail and J. Zhang, “Post-harvest Citrus diseases and their control. In: Post-harvest Citrus disease control,” Outlooks on pest Management, pp 29–35, 2004. Doi:10.1564.
J.J. Kim and S. Ben–Yehoshua, “Histological detection of phytoalexin scoparone from heat-treated and UV – illuminated lemon fruits after inoculation with Penicillium digitatum,” Plant Pathology, vol. 17(5), pp. 271–275, 2001.
P.A. Moscoso-Ramirez and L. Palou, “Potassium silicate: a new organic tool for the control of citrus postharvest green mold,” Acta Horticulturae, vol. 1144, pp. 287 – 291, 2016.
C. Nunes, J.M. Garcia, T. Manso, R. Torres, M. Olmo, J. Usall, “Effects of postharvest curing treatment on quality of Citrus fruit,” Vegetable Crops Research Bulletin, vol. 66, pp. 213–220, 2007. doi:10.2478/v10032-007-0024-6.
L. Palou, J.L. Smilanick, J. Usall and I. Vinas, “Control of postharvest blue and green molds of Oranges by hot water, sodium carbonate, and sodium bicarbonate,” Plant Disease, vol. 85, pp. 371–376, 2001.
L. Palou, “Penicillium digitatum, Penicillium italicum (Green mold, blue mold)”, In: Bautista S-Banos (Ed). Postharvest decay – Control strategies. Academic Press, pp. 45–102, 2014.
P. Plaza, J. Usall, R. Torres, N. Lamarca, A. Asensio, I. Vinas, “Control of green and blue mould by curing on oranges during ambient and cold storage,”. Postharvest Biology and Technology, vol. 28(1), pp. 195–198, 2003. https://doi.org/10.1016/S0925-5214(02)00127-8
P. Plaza, A. Sanbruno, J. Usall, N. Lamarca, R. Torres … V. Immaculada, “Integration of curing treatments with degreening to control the main postharvest diseases of ‘Clementine’ mandarins,”. Postharvest Biology and Technology, vol. 34, pp. 29 – 37, 2004.
R. Porat, A. Daus, B. Weiss, L. Cohen, E. Fallik, S. Droby, “Reduction of postharvest decay in organic citrus fruit by a short hot water brushing treatment,”. Postharvest Biology and Technology, vol. 18(1), pp. 151–157, 2000. https://doi.org/10.1016/S0925-5214(99)00065-4
V. Rodov, S. Ben-Yehoshua, R. Albagli, D.Q. Fang, “Reducing chilling injury and decay of stored citrus fruit by hot water dips,” Postharvest Biology and Technology, vol. 5, pp. 119 – 127, 1995.
M. Schirra, G. D’hallewin, “Storage performance of Fortune mandarins following hot water dips,” Postharvest Biology and Technology, vol. 10, pp. 229 – 238, 1997.
M. Schirra, M. Agabbio, G. D’hallewin, M. Pala, R. Ruggiu, “Response of Tarocco oranges to picking date, postharvest hot water dips, and chilling storage temperature,” J Agric. Food Chem, vol. 45, pp. 3216 – 3220, 1997.
M. Schirra, G. Barbera, G. D’Hallewin, P. Inglese and T. La Mantia, “Storage response of Cactus pear fruit to CaCl2 preharvest spray and postharvest heat treatment,” Journal of Horticultural Science, vol. 72(3), pp. 371–377, 1997.
M. Schirra, G. D’hallewin, S. Ben–Yehoshua and E. Fallik, “Host – pathogen interactions modulated by heat treatment,” Postharvest Biology and Technology, vol. 21, pp. 71 – 85, 2000.
JL. Smilanick, D. Sorensen, M. Mansour, J. Aieyabei and P. Plaza, “Impact of a brief postharvest hot water drench treatment on decay, fruit appearance and microbe populations of California lemons and oranges,” Hortechnology, vol. 13, pp. 333 – 338, 2003.
N. Tzortzakis, “Gaseous ozone- enrichment for the preservation of fresh produce,” Acta Horticulturae, vol. 1079, pp. 273 – 279, 2015.
M.H. Williams, M.A. Brown, M. Vesk and C. Brady, “Effect of postharvest heat treatments on fruit quality, surface structure, and fungal disease in Valencia oranges,” Australian Journal of Experimental Agriculture, vol. 34(8), pp. 1183 – 1190, 1994.
J. Zhang, “Lasiodiplodia theobromae in Citrus fruit (Diplodia stem – end rot) In: Postharvest Decay–Control strategies,” Academic Press. pp. 309-335, 2014. https://doi.org/10.1016/B978-0-12-411552-1.00010-7.
DOI: https://doi.org/10.46676/ij-fanres.v6i1.431
Refbacks
- There are currently no refbacks.
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.